玻璃幕墻日常保潔注意事項

發布時間:2014-03-02 瀏覽:

    華麗的建筑在燈光的映襯下更加奪目，晶瑩的玻璃幕墻讓城市更加流光溢彩，閃爍的城市讓新型建筑材料大有市場。當通體透明的建筑拔地而起的時候，當我們陶醉于玻璃幕墻制造的絢麗和嫵媚的時候，它的清潔問題也不容忽視。

    哈利法大樓幕墻安裝是個巨大工程，由350名中國專業技工安裝了整整14個月。勞動的高峰期，每天要裝好175塊面板。每完成一整組的安裝，都有檢測人員用類似二戰戰機螺旋槳式的發動機組向玻璃表面噴灑水和沙塵。為了擦玻璃，在大樓40層、73層和109層裝有特殊軌道和隱藏在轉角的升降機，36名清潔工能夠一起工作，可是，在正常氣候條件下，擦一遍也需要三四個月，哈利法大樓幕墻部分也堪稱世界奇跡。

    在清潔高空玻璃幕墻的時候，首先查看作業現場，確定作業方案。重點查看屋頂狀況，確定能否安裝吊籃、吊板，吊籃、吊板在屋頂移動有無障礙；霓虹燈、字牌有無防礙作業等。然后再安裝運載工具，如大廈已安裝擦窗機，則按規范做操作前的檢測。

    作業人員攜帶工具上吊籃或吊板，有些工具應拴在吊籃或吊板上，以防不小心失手落下，傷了行人。在地面設安全防護攔繩，或置安全警告牌。作業方式從上到下。每擦拭完一行，整理工具、加清洗劑、橫向移動吊板或吊籃，再繼續下一行作業。

    在施工的時檢查玻璃上有無粘著物等污跡，如有，先用刮刀等相應輔助工具和溶劑除去。將涂水器浸入桶中，待充分吸入清潔劑后用手輕輕捋一下（以不往下滴水為宜），均勻涂在玻璃上。涂抹時，一般由上往下滾，橫向移動，每趟滾跡要交叉相壓，以防漏涂。用膠刮將玻璃上的清潔劑刮凈，操作時應稍用力，將膠刮均勻按壓在玻璃上，由上往下緩緩刮動，每刮完一行，用濕毛巾將膠刮擦拭干凈再刮下一行。

    施工后期確認一次應作業范圍內的墻面已清洗完畢，滑動吊籃或吊板繼續往下作業。全部作業完成后，收拾整理設備和工具，撤離地面防護攔繩或警告牌，將地面水跡擦凈。

  Ornate building more eye-catching in the light against the background, glistening glass walls make the city more bright colors , flashing a great city to allow new building materials market . When the body transparent building going up , and when we revel in the splendor of the glass curtain wall manufacturing and charming when it 's clean can not be ignored .

 Khalifa building curtain wall installation is a huge project , the 350 Chinese professional technicians installed a full 14 months. The peak of the labor day to installed 175 panels. Each complete the installation of a whole group of people with a World War II fighter planes have detected similar propeller engine block spray water and dust to the glass surface. To Cabo , the 40-story building , 73 layers and layer 109 is equipped with special tracks and hide in the corner of the elevator , 36 cleaners can work together , but , under normal weather conditions, wipe it needs three or four months , part of the building facade Khalifa also called wonders of the world .

 Clean the glass wall at high altitude , the first view the job site , to determine the operating plan. Focus your roof condition , to determine whether the installation of hanging baskets, hanging panels, hanging baskets, hanging panels on the roof to move Accessible ; neon , plates or without hinder job and so on. Then install a vehicle , such as the gondola building has been installed , press the norm to do testing before the operation .

 Workers carry the tools hanging basket or plate , some tools should be tied in hanging baskets or board , to prevent accidentally missed fall, hurt pedestrians. Safety bar located on the ground rope, or home safety warning signs . Practices from top to bottom . Each wipe finish line , finishing tools, plus cleaning agents, boatswain's chair or lateral movement of the basket , and then continue to the next line operations.

 During the construction of the glass when checking whether the adhesive material , such as stains , if any , is removed with a scraper and other appropriate first aid and solvents. After coated with water immersion bucket , to be fully inhale gently stroked cleaner look ( with no dripping appropriate ) , evenly coated on the glass . When applied , the general roll from top to bottom , lateral movement , every trip to the cross -phase pressure roller tracks to leak painted . With a squeegee to scrape the glass cleaner , the operation should be a little harder , push the squeegee evenly on the glass , from top to bottom slowly scraping every scraped off line with a wet towel to wipe the squeegee again scraped line.

 Post- construction should be confirmed once the wall has been cleaned within the operating range of the finished sliding plate hanging basket or continue down the job . After all the job is complete, clean finishing equipment and tools , evacuation floor protective barrier rope or warning signs , wipe the surface water traces .